DataSheet39.com

What is ISL6446A?

This electronic component, produced by the manufacturer "Intersil", performs the same function as "Dual PWM and Linear Controller".


ISL6446A Datasheet PDF - Intersil

Part Number ISL6446A
Description Dual PWM and Linear Controller
Manufacturers Intersil 
Logo Intersil Logo 


There is a preview and ISL6446A download ( pdf file ) link at the bottom of this page.





Total 20 Pages



Preview 1 page

No Preview Available ! ISL6446A datasheet, circuit

DATASHEET
Dual (180°Out-of-Phase) PWM and Linear Controller
ISL6446A
The ISL6446A is a high-performance, triple output controller
that provides a single high-frequency power solution primarily
for Broadband, DSL and Networking applications. This device
integrates complete control, monitoring and protection
functions for two synchronous buck PWM controllers and one
linear controller. Input voltage ripple and total RMS input
current is substantially reduced by synchronized 180°
out-of-phase operation of the two PWMs.
The two PWM buck converters provide simple voltage mode
control. The output voltage of the converters can be precisely
regulated to as low as 0.6V, with a maximum tolerance of
±1.5% over-temperature and line variations. Programmable
switching frequency down to 100kHz provides optimized low
cost solution for ATX power supplies. It is also able to operate
up to 2.5MHz to deliver compact solutions. The linear
controller provides a low-current output.
Each PWM controller has soft-start and independent enable
functions combined on a single pin. A capacitor from SS/EN to
ground sets the soft-start time; pulling SS/EN pin below 1V
disables the controller. Both outputs can soft-start into a
prebiased load.
The ISL6446A incorporates robust protection features. An
adjustable overcurrent protection circuit monitors the output
current by sensing the voltage drop across the upper MOSFET
rDS(ON). Latch-off mode overcurrent operation protects the
DC/DC converters from damage under overload and
short-circuit conditions. A PGOOD signal is issued when
soft-start is complete and PWM outputs are within 10% of
their regulated values and the linear regulator output is higher
than 75% of its nominal value. Thermal shutdown circuitry
turns the device off if the IC temperature exceeds +150°C.
Features
• 4.5V to 5.5V or 5.5V to 24V input voltage range
• Three programmable power output voltages
- Two PWM controllers with out-of-phase operation
- Voltage-mode PWM control
- One linear controller
• Programmable switching frequency from 100kHz to 2.5MHz
• Fast transient response
- High-bandwidth error amplifier
• Extensive circuit protection functions
- Undervoltage, and over-temperature
- Overvoltage with latch-off mode
- Programmable overcurrent limit with latch-off mode
- Lossless current sensing (no sense resistor needed)
• Externally adjustable soft-start time
- Independent enable control
- Voltage tracking capability
- Able to soft-start into a prebiased load
• PGOOD output with delay
Applications
• ATX power supplies
• DSP, ASIC, and FPGA point-of-load regulation
• Industrial and security networking applications
VOUT1
VOUT2
Feedback
and
Compensation
Network
R1
Feedback
and
Compensation
Network
R2
VCC VIN
CVCC
ROCSET1
VCC
COMP1
FB1
VIN
OCSET1 CBOOT1
BOOT1
UGATE1
VIN1 = VIN
COCSET1
CIN1
Q1
COMP2
FB2
PHASE1
LGATE1
L1
Q2
VOUT1
COUT1
ISL6446A
ROCSET2
OCSET2 CBOOT2
BOOT2
VIN2 = VIN
COCSET2
CIN2
PGOOD
RT
SS/EN1
SS/EN2
UGATE2
PHASE2
LGATE2
LCDR
LCFB
Q3
L2
Q4
VOUT2
COUT2
SGND PGND
FIGURE 1. TYPICAL APPLICATION
100
98
96
94
92
90 VOUT = 3.3V
VOUT = 5V
88
86
84
82
80 0 5 10 15 20
LOAD CURRENT (A)
FIGURE 2. EFFICIENCY vs LOAD CURRENT (OBTAINED FROM
ISL6446AEVAL1Z)
25
August 27, 2015
FN8384.3
1
CAUTION: These devices are sensitive to electrostatic discharge; follow proper IC Handling Procedures.
1-888-INTERSIL or 1-888-468-3774 | Copyright Intersil Americas LLC 2012, 2013, 2015. All Rights Reserved
Intersil (and design) is a trademark owned by Intersil Corporation or one of its subsidiaries.
All other trademarks mentioned are the property of their respective owners.

line_dark_gray
ISL6446A equivalent
ISL6446A
Typical Application Schematic
VOLTAGE INPUTS REQUIRED
VIN (4.5V TO 24V) = VIN1 = VIN2
VCC (5V; INTERNAL IF VIN > 5.6V)
VIN3 (VCC) FOR LINEAR
TYPE-3 COMPENSATION SHOWN
C102
VOUT1
R102
R101
C101
R103
C103
C202
R100
VOUT2
R202
R201
C201
R203 C203
R200
TYPE-3 COMPENSATION SHOWN
VCC
RPGOOD
CSS1/EN1 CSS2/EN2 RRT
VCC
VCC
CVCC CVIN
VIN
OPTIONAL
CONNECTION
(FOR VIN = VCC = 5V)
ROCSET1
VIN
VIN1 = VIN
COMP1
FB1
OCSET1
BOOT1
COCSET1
CBOOT1
Q101
CIN1
UGATE1
PHASE1
0.9µH
L100
VOUT1
COMP2
FB2
PGOOD
RT
SS1/EN1
SS2/EN2
ISL6446A
LGATE1
Q102
2x680µF/18m
2x100µF
1x47µF
ROCSET2
VIN2 = VIN
COUT1
OCSET2
BOOT2
UGATE2
PHASE2
LGATE2
COCSET2
CBOOT2
Q201
CIN2
0.9µH
L200
Q202
LCDR
R303
R304
C301 R302
Q301
VOUT2
COUT2
2x680µF/18m
2x100µF
VIN3
CIN3
SGND
PGND
LCFB
R300
R301
VOUT3
COUT3
FIGURE 4. ISL6446A TYPICAL APPLICATION
Submit Document Feedback
5
FN8384.3
August 27, 2015


line_dark_gray

Preview 5 Page


Part Details

On this page, you can learn information such as the schematic, equivalent, pinout, replacement, circuit, and manual for ISL6446A electronic component.


Information Total 20 Pages
Link URL [ Copy URL to Clipboard ]
Download [ ISL6446A.PDF Datasheet ]

Share Link :

Electronic Components Distributor


An electronic components distributor is a company that sources, stocks, and sells electronic components to manufacturers, engineers, and hobbyists.


SparkFun Electronics Allied Electronics DigiKey Electronics Arrow Electronics
Mouser Electronics Adafruit Newark Chip One Stop


Featured Datasheets

Part NumberDescriptionMFRS
ISL6446The function is Dual PWM and Linear Controller. IntersilIntersil
ISL6446AThe function is Dual PWM and Linear Controller. IntersilIntersil

Semiconductors commonly used in industry:

1N4148   |   BAW56   |   1N5400   |   NE555   |  

LM324   |   BC327   |   IRF840  |   2N3904   |  



Quick jump to:

ISL6     1N4     2N2     2SA     2SC     74H     BC     HCF     IRF     KA    

LA     LM     MC     NE     ST     STK     TDA     TL     UA    



Privacy Policy   |    Contact Us     |    New    |    Search